Investigating the performance of a Novel Deep feeding technique in All-Water Evacuated tube Collectors for Solar Desalination Systems.

Mohamed A. Essa, El-Sayed Ibrahim Abdel Aziz

Abstract


Water desalination is one of the most branches investigated due to freshwater scarcity. One of the most effective water desalination techniques is solar desalination. Solar desalination works better under higher temperatures of water as it increases the evaporation and desalination rates. Evacuated tube solar collector (ETSC) presents an advantage as a solar water heater in medium temperature ranges and is suitable for solar desalination. The enhancement of its performance has been a hot topic in the last years due to its high efficiency at high temperatures. However, the techniques with which the ETSC implemented, differs in storage availability as in the all-water systems, good heat transfer as in the direct flow system. In the present research a novel technique combining the benefits of both all-water and direct flow systems is presented to increase the temperature of the heated water. The combined system considers the injection of the feed water inside the ETSC directly to make use of forced convection heat transfer and destruct the stagnation zone in the bottom of the tubes. Three water flow rates of 2, 4, 8 LPH were tested. The combined system achieved an enhancement in the thermal efficiency and the maximum temperature getting out from the ETSC by 27% and 14.7%, respectively, at a flow rate of 8 LPH. Moreover, the overall efficiency was enhanced by up to 27.3%, compared to all-water system. The economic study showed that the cost of heated water with the proposed system over the traditional system reaches 0.00195 $/kw.hr for 8 LPH extraction rate. Due to this increase in the system temperature, the proposed techniques can be applied for solar desalination. The numerical simulation results found to agree with the experimental results by 5.4% relative error.

Keywords


ETSC; efficiency; Outdoor test; solar desalination; Experimental; Numerical.

Full Text:

PDF

References


G. N. Tiwari AKT. Solar Distillation Practice for Water Desalination Systems. 1st ed. Anshan Publishers; 2008.

Chopra K, Tyagi V V, Pathak AK, Pandey AK, Sari A. Experimental performance evaluation of a novel designed phase change material integrated manifold heat pipe evacuated tube solar collector system. Energy Convers Manag 2019;198:111896. https://doi.org/https://doi.org/10.1016/j.enconman.2019.111896.

Essa MA, Rofaiel IY, Ahmed MA. Experimental and Theoretical Analysis for the Performance of Evacuated Tube Collector Integrated with Helical Finned Heat Pipes using PCM Energy Storage. Energy 2020;206:118166. https://doi.org/10.1016/j.energy.2020.118166.

Alshukri MJ, Eidan AA, Najim SI. Thermal performance of heat pipe evacuated tube solar collector integrated with different types of phase change materials at various location. Renew Energy 2021;171:635–46. https://doi.org/https://doi.org/10.1016/j.renene.2021.02.143.

Tamuli BR, Saikia SS, Nath S, Bhanja D. Thermal performance analysis of a co-axial evacuated tube collector with single and two-phase flow consideration under North-eastern India climatic condition. Sol Energy 2020;196:107–24. https://doi.org/https://doi.org/10.1016/j.solener.2019.11.097.

Olfian H, Ajarostaghi SSM, Farhadi M, Ramiar A. Melting and solidification processes of phase change material in evacuated tube solar collector with U-shaped spirally corrugated tube. Appl Therm Eng 2021;182:116149. https://doi.org/https://doi.org/10.1016/j.applthermaleng.2020.116149.

Rezaeian M, Shafiey Dehaj M, Zamani Mohiabadi M, Salarmofrad M, Shamsi S. Experimental investigation into a parabolic solar collector with direct flow evacuated tube. Appl Therm Eng 2021;189:116608. https://doi.org/https://doi.org/10.1016/j.applthermaleng.2021.116608.

Naik BK, Bhowmik M, Muthukumar P. Experimental investigation and numerical modelling on the performance assessments of evacuated U – Tube solar collector systems. Renew Energy 2019;134:1344–61. https://doi.org/https://doi.org/10.1016/j.renene.2018.09.066.

Korres DN, Tzivanidis C, Koronaki IP, Nitsas MT. Experimental, numerical and analytical investigation of a U-type evacuated tube collectors’ array. Renew Energy 2019;135:218–31. https://doi.org/https://doi.org/10.1016/j.renene.2018.12.003.

Nitsas MT, Koronaki IP. Experimental and theoretical performance evaluation of evacuated tube collectors under mediterranean climate conditions. Therm Sci Eng Prog 2018;8:457–69. https://doi.org/https://doi.org/10.1016/j.tsep.2018.10.001.

Bhowmik M, Muthukumar P, Anandalakshmi R. Experimental based multilayer perceptron approach for prediction of evacuated solar collector performance in humid subtropical regions. Renew Energy 2019;143:1566–80. https://doi.org/https://doi.org/10.1016/j.renene.2019.05.093.

Liang R, Ma L, Zhang J, Zhao D. Theoretical and experimental investigation of the filled-type evacuated tube solar collector with U tube. Sol Energy 2011;85:1735–44. https://doi.org/https://doi.org/10.1016/j.solener.2011.04.012.

Gao Y, Zhang Q, Fan R, Lin X, Yu Y. Effects of thermal mass and flow rate on forced-circulation solar hot-water system: Comparison of water-in-glass and U-pipe evacuated-tube solar collectors. Sol Energy 2013;98:290–301. https://doi.org/https://doi.org/10.1016/j.solener.2013.10.014.

Tong Y, Kim J, Cho H. Effects of thermal performance of enclosed-type evacuated U-tube solar collector with multi-walled carbon nanotube/water nanofluid. Renew Energy 2015;83:463–73. https://doi.org/https://doi.org/10.1016/j.renene.2015.04.042.

Kabeel AE, Abdelgaied M, Elrefay MKM. Thermal performance improvement of the modified evacuated U-tube solar collector using hybrid storage materials and low-cost concentrators. J Energy Storage 2020;29:101394. https://doi.org/https://doi.org/10.1016/j.est.2020.101394.

Kaya H, Arslan K, Eltugral N. Experimental investigation of thermal performance of an evacuated U-Tube solar collector with ZnO/Etylene glycol-pure water nanofluids. Renew Energy 2018;122:329–38. https://doi.org/https://doi.org/10.1016/j.renene.2018.01.115.

Essa MA, Asal M, Saleh MA, Shaltout RE. A comparative study of the performance of a novel helical direct flow U-Tube evacuated tube collector. Renew Energy 2021;163:2068–80. https://doi.org/https://doi.org/10.1016/j.renene.2020.10.109.

Veera Kumar A, Arjunan T V, Seenivasan D, Venkatramanan R, Vijayan S. Thermal performance of an evacuated tube solar collector with inserted baffles for air heating applications. Sol Energy 2021;215:131–43. https://doi.org/https://doi.org/10.1016/j.solener.2020.12.037.

Sadhishkumar S, Balusamy T. Performance improvement in solar water heating systems—A review. Renew Sustain Energy Rev 2014;37:191–8. https://doi.org/https://doi.org/10.1016/j.rser.2014.04.072.

Mojtaba Tabarhoseini S, Sheikholeslami M. Modeling of evacuated tube solar collector involving longitudinal fins and nanofluids. Sustain Energy Technol Assessments 2022;53:102587. https://doi.org/https://doi.org/10.1016/j.seta.2022.102587.

Chai S, Yao J, Liang J-D, Chiang Y-C, Zhao Y, Chen S-L, et al. Heat transfer analysis and thermal performance investigation on an evacuated tube solar collector with inner concentrating by reflective coating. Sol Energy 2021;220:175–86. https://doi.org/https://doi.org/10.1016/j.solener.2021.03.048.

Bracamonte J. Effect of the transient energy input on thermodynamic performance of passive water-in-glass evacuated tube solar water heaters. Renew Energy 2017;105:689–701. https://doi.org/https://doi.org/10.1016/j.renene.2016.12.051.

Jowzi M, Veysi F, Sadeghi G. Experimental and numerical investigations on the thermal performance of a modified evacuated tube solar collector: Effect of the bypass tube. Sol Energy 2019;183:725–37. https://doi.org/https://doi.org/10.1016/j.solener.2019.03.063.

Li S-F, Liu Z-H, Shao Z-X, Xiao H, Xia N. Performance study on a passive solar seawater desalination system using multi-effect heat recovery. Appl Energy 2018;213:343–52. https://doi.org/https://doi.org/10.1016/j.apenergy.2018.01.064.

Behnam P, Shafii MB. Examination of a solar desalination system equipped with an air bubble column humidifier, evacuated tube collectors and thermosyphon heat pipes. Desalination 2016;397:30–7. https://doi.org/https://doi.org/10.1016/j.desal.2016.06.016.

Abbaspour MJ, Faegh M, Shafii MB. Experimental examination of a natural vacuum desalination system integrated with evacuated tube collectors. Desalination 2019;467:79–85. https://doi.org/10.1016/j.desal.2019.06.004.

Fath HES, El-Samanoudy M, Fahmy K, Hassabou A. Thermal-economic analysis and comparison between pyramid-shaped and single-slope solar still configurations. Desalination 2003;159:69–79. https://doi.org/https://doi.org/10.1016/S0011-9164(03)90046-4.




DOI (PDF): https://doi.org/10.20508/ijrer.v13i3.13895.g8779

Refbacks

  • There are currently no refbacks.


Online ISSN: 1309-0127

Publisher: Gazi University

IJRER is cited in SCOPUS, EBSCO, WEB of SCIENCE (Clarivate Analytics);

IJRER has been cited in Emerging Sources Citation Index from 2016 in web of science.

WEB of SCIENCE in 2025; 

h=35,

Average citation per item=6.59

Last three Years Impact Factor=(1947+1753+1586)/(146+201+78)=5286/425=12.43

Category Quartile:Q4