Evaluation of Effects of Compression Ratio on Performance, Combustion, Emission, Noise and Vibration Characteristics of a VCR Diesel Engine

Şafak Yıldızhan, Erinç ULUDAMAR, Mustafa ÖZCANLI, Hasan SERİN

Abstract


In this study, an experimental study has been evaluated on a variable compression ratio diesel engine to investigate the compression ratio effects on engine performance, combustion, emission, vibration, and noise characteristics. The result of engine characteristics were studied at 12:1, 14:1, and 16:1 compression ratios under partial load condition. Experimental engine was operated with diesel, biodiesel and diesel-biodiesel blends throughout the experiments. Experimental study indicated that compression ratio considerably affects the engine characteristics that measured in this study. It is observed that in the experiments, higher compression ratio results in higher brake thermal efficiency and thus lower specific fuel consumption. Higher compression ratios resulted with higher cylinder pressure and thus improved combustion. Increasing compression ratio improved carbon monoxide emission, however, increased carbon dioxide emission and nitrogen oxides formation. Also, noise and vibration of the engine reduced with the increment of compression ratio.

Keywords


Compression ratio; Performance; Emission; Noise; Vibration

Full Text:

PDF

References


A. Demirbas, “Biodiesel production from vegetable oils via catalytic and non-catalytic supercritical methanol transesterification methodsâ€, Prog Energ Combust, vol.31, pp.466-487, 2005.

H.K. Amarnath, and P. Prabhakaran, “A Study on the Thermal Performance and Emissions of a Variable Compression Ratio Diesel Engine Fuelled with Karanja Biodiesel and the Optimization of Parameters Based on Experimental Dataâ€, Int J Green Energy, vol.9, pp.841-863, 2012.

T. Hoeltgebaum, R. Simoni, and D. Martins, Reconfigurability of engines: “A kinematic approach to variable compression ratio enginesâ€, Mech Mach Theory, vol.96, pp.308-322, 2016.

S. Jindal, B.P. Nandwana, N.S. Rathore, and V. Vashistha, “Experimental investigation of the effect of compression ratio and injection pressure in a direct injection diesel engine running on Jatropha methyl esterâ€, Appl Therm Eng, vol.30, pp. 442-448, 2010.

K. Muralidharan, and D. Vasudevan, “Performance, emission and combustion characteristics of a variable compression ratio engine using methyl esters of waste cooking oil and diesel blendsâ€, Appl Energ, vol.88, pp.3959-3968, 2011.

H. Serin, M. Ozcanli, M.K. Gokce, and G. Tuccar, “Biodiesel Production From Tea Seed (Camellia Sinensis) Oil and its Blends With Diesel Fuelâ€, Int J Green Energy, vol.10, pp.370-377, 2013.

M. Balat, “Biodiesel fuel production from vegetable oils via supercritical ethonol transesterificationâ€, Energ Source Part A, vol.30, pp.429-440, 2008.

A. Demirbas, “Biodegradability of Biodiesel and Petrodiesel Fuelsâ€, Energ Source Part A, vol.31, pp.169-174, 2009.

A. Demirbas, “Tea seed upgrading facilities and economic assessment of biodiesel production from tea seed oilâ€, Energ Convers Management, vol.51, pp.2595-2599, 2010.

C.P. Sigar, S.L. Soni, J. Mathur, and D. Sharma, “Performance and Emission Characteristics of Vegetable Oil as Diesel Fuel Extenderâ€, Energ Source Part A, vol.31, pp.139-148, 2009.

S. Altun, “Fuel properties of biodiesels produced from different feedstocksâ€, Ener Educ Sci Tech-A, vol.26, pp.165-174, 2011.

F. Anwar, U. Rashid, M. Ashraf, and M. Nadeem, “Okra (Hibiscus esculentus) seed oil for biodiesel productionâ€, Appl Energ, vol.87, pp.779-785, 2010.

T. Balusamy, and R. Marappan, “Effect of Injection Time and Injection Pressure on CI Engine Fuelled with Methyl Ester of Thevetia Peruviana Seed Oilâ€, Int J Green Energy, vol.7 pp.397-409, 2010.

O.Y. Saribiyik, M. Ozcanli, H. Serin, S. Serin, and K. Aydin, “Biodiesel Production from Ricinus Communis Oil and Its Blends with Soybean Biodieselâ€, Stroj Vestn-J Mech E, vol.56, pp.811-816, 2010.

S. Caynak, M. Guru, A. Bicer, A. Keskin, and Y. Icingur, “Biodiesel production from pomace oil and improvement of its properties with synthetic manganese additiveâ€, Fuel, vol.88, pp.534-538, 2009.

M. Canakci, and J.H. Van Gerpen,†Comparison of engine performance and emissions for petroleum diesel fuel, yellow grease biodiesel, and soybean oil biodieselâ€, T Asae, vol.46, pp.937-944, 2003.

M. Ozcanli, A. Keskin, and K. Aydin, “Biodiesel Production from Terebinth (Pistacia Terebinthus) Oil and Its Usage in Diesel Engineâ€, Int J Green Energy, vol.8, pp.518-528, 2011.

N. Usta, “An experimental study on performance and exhaust emissions of a diesel engine fuelled with tobacco seed oil methyl esterâ€, Energ Convers Management, vol.46, pp.2373-2386, 2005.

N. Usta, “Use of tobacco seed oil methyl ester in a turbocharged indirect injection diesel engineâ€, Biomass Bioenerg, vol.28, pp.77-86, 2005.

C. Hamamci, A. Saydut, Y. Tonbul, C. Kaya, and A.B. Kafadar, “Biodiesel Production via Transesterification from Safflower (Carthamus tinctorius L.) Seed Oilâ€, Energ Source Part A, vol.33, pp.512-520, 2011.

M.A. Akar, “Performance and emission characteristics of compression ignition engine operating with false flax biodiesel and butanol blendsâ€, Adv Mech Eng, vol.8, 2016.

M. Ozcanli, H. Serin, K. Aydin, and S. Serin, “Ricinus Communis (Castor Oil) methyl ester as a natural additive for biodiesel fuelsâ€, Ener Educ Sci Tech-A, vol.27, 331-336, 2011.

K. Celebi, E. Uludamar, E. Tosun, S. Yildizhan, K. Aydin, and M. Ozcanli, “Experimental and artificial neural network approach of noise and vibration characteristic of an unmodified diesel engine fuelled with conventional diesel, and biodiesel blends with natural gas additionâ€, Fuel, vol.197, 159-173, 2017.

K. Celebi, E. Uludamar, and M. Ozcanli, “Evaluation of fuel consumption and vibration characteristic of a compression ignition engine fuelled with high viscosity biodiesel and hydrogen additionâ€, International Journal of Hydrogen Energy, http://dx.doi.org/10.1016/j.ijhydene.2017.02.066.

P.K. Srivastava, and M. Verma, “Methyl ester of karanja oil as an alternative renewable source energyâ€, Fuel, vol.87, 1673-1677, 2008.

H.G. How, H.H. Masjuki, M.A. Kalam, and Y.H. Teoh, “An investigation of the engine performance, emissions and combustion characteristics of coconut biodiesel in a high-pressure common-rail diesel engineâ€, Energy, vol.69, 749-759, 2014.

A. Taghizadeh-Alisaraei, B. Ghobadian, T. Tavakoli-Hashjin, and S.S. Mohtasebi, “Vibration analysis of a diesel engine using biodiesel and petrodiesel fuel blendsâ€, Fuel, vol.102, pp.414-422, 2012.

I. Gravalos, S. Loutridis, D. Moshou, T. Gialamas, D. Kateris, Z. Tsiropoulos, and P. Xyradakis, “Detection of fuel type on a spark ignition engine from engine vibration behaviourâ€, Appl Therm Eng, vol.54, pp.171-175, 2013.

A. Sanjid, H.H. Masjuki, M.A. Kalam, S.M.A. Rahman, M.J. Abedin, M.I. Reza, and H. Sajjad, “Experimental investigation of palm-jatropha combined blend properties, performance, exhaust emission and noise in an unmodified diesel engineâ€, Procedia Engineering, vol.90, pp.397-402, 2014.

A.J. Torregrosa, A. Broatch, B. Pla, and L.F. Monico,†Impact of Fischer-Tropsch and biodiesel fuels on trade-offs between pollutant emissions and combustion noise in diesel enginesâ€, Biomass Bioenerg, vol.52, pp.22-33, 2013.

C. Sayin, M.K. Balki, “Effect of compression ratio on the emission, performance and combustion characteristics of a gasoline engine fueled with iso-butanol/gasoline blendsâ€, Energy, vol.82, pp.550-555, 2015.

H.H. Masjuki, A.M. Ruhul, N.N. Mustafi, M.A. Kalam, M.I. Arbab, and I.M.R. Fattah,†Study of production optimization and effect of hydroxyl gas on a CI engine performance and emission fueled with biodiesel blendsâ€, Int J Hydrogen Energ, vol.41, 14519-14528, 2016.

V. Gnanamoorthi, G. Devaradjane, Effect of compression ratio on the performance, combustion and emission of DI diesel engine fueled with ethanol - Diesel blend, J Energy Inst, vol.88, pp.19-26, 2015.

S.K. Nayak, S.K. Nayak, P.C. Mishra, and S. Tripathy, “Influence of compression ratio on combustion characteristics of a VCR engine using Calophyllum inophyllum biodiesel and diesel blendsâ€, J Mech Sci Technol, vol.29, pp.4047-4052, 2015.

A. Pal, and A.K. Agarwal, “Effect of compression ratio on combustion, performance and emissions of a laser ignited single cylinder hydrogen engineâ€, Int J Hydrogen Energ, vol.40, pp.12531-12540, 2015.

L. Li, J.X. Wang, Z. Wang, and J.H. Xiao, “Combustion and emission characteristics of diesel engine fueled with diesel/biodiesel/pentanol fuel blendsâ€, Fuel, vol.156, 211-218, 2015.

L. Zhu, W.G. Zhang, W. Liu, and Z. Huang, “Experimental study on particulate and NOx emissions of a diesel engine fueled with ultra low sulfur diesel, RME-diesel blends and PME-diesel blendsâ€, Sci Total Environ, vol.408, pp.1050-1058, 2010.

M. Vasudeva, S. Sharma, S.K. Mohapatra, and K. Kundu, “Performance and exhaust emission characteristics of variable compression ratio diesel engine fuelled with esters of crude rice bran oilâ€, Springerplus, vol.5, 2016.

E.G. Giakoumis, D.C. Rakopoulos, and C.D. Rakopoulos, “Combustion noise radiation during dynamic diesel engine operation including effects of various biofuel blends: A reviewâ€, Renew Sust Energ Rev, vol.54, pp.1099-1113, 2016.

M.D. Redel-Macias, R.D. Rodriguez-Cantalejo, S. Pinzi, A.J. Cubero-Atienza, and M.P. Dorado, “Evaluation of sound quality in a tractor driver cabin based on the effect of biodiesel fatty acid compositionâ€, Fuel, vol.118, pp.194-201, 2014.




DOI (PDF): https://doi.org/10.20508/ijrer.v8i1.6573.g7284

Refbacks

  • There are currently no refbacks.


Online ISSN: 1309-0127

Publisher: Gazi University

IJRER is cited in SCOPUS, EBSCO, WEB of SCIENCE (Clarivate Analytics);

IJRER has been cited in Emerging Sources Citation Index from 2016 in web of science.

WEB of SCIENCE in 2025; 

h=35,

Average citation per item=6.59

Last three Years Impact Factor=(1947+1753+1586)/(146+201+78)=5286/425=12.43

Category Quartile:Q4